benefits l used in potentially explosi ve atmospheres l enhanced capacity l high voltage response, stable during most of the lifetime of the application l wide operating temperature range ( - 6 0 c/ + 8 5 c) l low self-discharge rate (less than 1 % after 1 year of storage at + 2 0 c) key features l non-flammable electrolyte l compliant with iec 60079-11 intrinsic safety standard and iec 60086-4 safety standard l stainless steel container and end caps (low magnetic signature) l hermetic glass-to-metal sealing l underwriters laboratories (ul) component recognition l non-restricted for transport l manufactured in uk and china main applications l gas metering l automatic meter reading l alarms and security devices l miners cap lamps l gas detectors l air monitoring equipment l safety torches l gas tanks level monitoring l miner equipment primary lithium battery ls 14500ex 3.6 v primary lithium-thionyl chloride (li-socl 2 ) high energy density aa-size bobbin cell for demanding and potentially explosive atmospheres cell size references r6 - aa may 2010 electrical characteristics ( typical values relative to cells stored for one year or less at + 3 0 c max.) nominal capacity 2.6 ah (at 2 ma + 2 0 c 2.0 v cut-off. the capacity restored by the cell varies according to current drain, temperature and cut-off) open circuit voltage (at + 20 c) 3.67 v nominal voltage (at 0.2 ma + 20 c) 3.6 v nominal energy 9.36 wh pulse capability: typically up to 250 ma (250 ma/0.1 second pulses, drained every 2 mn at +2 0 c from undischarged cells with 10 a base current, yield voltage readings above 3.0 v. the readings may vary according to the pulse characteristics, the temperature, and the cells previous history. fitting the cell with a capacitor may be recommended in severe conditions. consult saf t) maximum recommended continuous current 50 ma (higher currents possible, consult sa f t) storage (recommended) + 30 c ( + 86 f) max (for more severe conditions, consult sa f t) operating temperature range - 60 c/ + 85 c (operation above ambient t may lead to reduced capacity and ( - 76 f/ + 185 f) lower voltage readings at the beginning of pulses. consult sa f t) physical characteristics diameter (max) 14.55 mm (0.57 in) height (max) 50.3 mm (1.98 in) typical weight 16.7 g (~ 0.6 oz) li metal content approx. 0.7 g available termination suffix cn, cnr radial tabs 2 pf, 3 pf, 3 pf rp, 4 pf radial pins cna (ax) axial leads fl flying leads... etc. iec 6007 9 -11 intrinsic safety characteristics (t4 up to + 55 c) i shor t- circuit current (max) 3.7 a ri (max) 989 mohm temperature rise (max) + 78 c new
ls 1 450 0 ex storage l the storage area should be clean, cool (preferably not exceeding + 3 0 c), dry and ventilated. warning l fire, explosion and burn hazard. l do not recharge, short circuit, crush, disassemble, heat above 10 0 c (212 f), incinerate, or expose contents to water. l do not solder directly to the cell (use tabbed cell versions instead). ? 4.2 min 5.5 max (flat area) ? 14.44 0.11 ? 7.5 0.1 1.35 0.3 50 0.3 0.4 0.1 dimensions in mm. 0.1 0.01 0.1 1 10 100 1000 2.2 2.4 2.6 2.8 3.0 3.2 3.4 3.6 3.8 2.2 2.0 0.0 0.2 0.4 0.6 0.8 1.0 1.2 1.4 1.6 1.8 2.0 2.2 2.4 2.6 2.8 3.0 2.4 2.6 2.8 3.0 3.2 3.4 3.6 3.8 1 10 100 1000 10000 0.1 1 10 100 1000 - 40oc 57 ohm s/ 55 ma 400 ohm s/ 8.6 ma 1000 ohm s/ 3.6 ma 3600 ohm s/ 1 ma - 20oc + 20oc + 55oc + 70oc doc. n o 3109 6-2- 0510 information in this document is subject to change without notice and becomes contractual only after written confirmation by saft. for more details on primary lithium technologies please refer to primary lithium batteries selector guide doc n o 31048-2. published by the communications department. photo credit: saft socit anonyme au capital de 31 944 000 rcs bobigny b 383 703 873 produced by arthur associates limited. saft specialty battery group 12, rue sadi carnot 93170 bagnolet - france tel.: +33 (0)1 49 93 19 18 fa x : +33 (0)1 49 93 19 69 www.saftbatteries.com current (ma) cell voltage (v) cell voltage (v) capacity (ah) time (hours) current (ma) restored capacity versus current and temperature (2.0 v cu t- off) typical discharge profiles at + 20c voltage plateau versus current and temperature (at mi d- discharge)
|
